Go to Top Go to Bottom
Kumar, Sharma, Ranjan, Kumar, Bhat, and Jeong: Perspective of Membrane Technology in Dairy Industry: A Review

Abstract

Membrane technology has revolutionized the dairy sector. Different types of membranes are used in the industry for various purposes like extending the shelf life of milk without exposure to heat treatment, standardization of the major components of milk for tailoring new products as well increasing yield and quality of the dairy products, and concentrating, fractionation and purification of milk components especially valuable milk proteins in their natural state. In the cheese industry, membranes increase the yield and quality of cheese and control the whey volume, by concentrating the cheese milk. With the advancement of newer technology in membrane processes, it is possible to recover growth factor from whey. With the introduction of superior quality membranes as well as newer technology, the major limitation of membranes, fouling or blockage has been overcome to a greater extent.

INTRODUCTION

The term “membrane technology” is used to collectively represent the separation processes by employing specific semi-permeable membrane filters to concentrate or fractionate a liquid into two liquids of different compositions (Winston and Sirkar, 1992) by selectively allowing some compounds to pass while encumbering the others. The liquid that is able to pass the membrane is known as “permeates” and the retained liquid is known as “retentate” or “concentrate”. The efficiency of membranes is largely governed by the hydrostatic pressure gradients (also known as “transmembrane pressure”) across the membrane and concentration gradient of the liquids. In few a cases, electric potential has important role (Winston and Sirkar, 1992).
The milk is considered as the best, ideal and a complete food and has an important place in human diet especially in vegetarian diet (Kumar and Rai, 2010; Shekhar et al., 2010; Kumar et al., 2011b; Shekhar and Kumar, 2011). The milk is an ideal liquid for membrane filtration due to its composition. Membrane technology has been applied in the dairy industry since the early 1960s and now comes the second behind the water treatment technology and serves as viable alternatives for more traditional dairy processes like distillation, evaporation or extraction. The food industry represents 20 to 30% of the current 250 million turnover of membranes worldwide with 7.5% annual growth. Several hundreds of thousand square meters of membrane (Ultrafiltration: 400,000; Nanofiltration: 300,000; Reverse osmosis: 100,000; Microfiltration: 50,000) are currently operating (Saxena et al., 2009). About 2/3 of the membrane area installed in the dairy industry is used for the treatment of whey and about 1/3 for milk (Saxena et al., 2009). The utilization of membranes in dairy industry has been greatly enhanced with the introduction of novel base materials viz. cellulose acetate, polyamides, polysulphons accompanied by newer technological processes such as reverse osmosis, diafiltration (DF) and nanofiltration (NF) (Figure 1). In the present scenario, different types of membrane separation technologies such as micro-filtration, ultra-filtration (Balannec et al., 2005), nano-filtration (Vourch et al., 2005) and reverse osmosis (RO) (Balannec et al., 2005; Vourch et al., 2005) are being made available for use in the dairy industry.
The use of membrane filtration technology offers a wide range of advantages for the consumer as well as for the producers. The membrane technology is a novel non thermal environmental friendly greener technology with full of future possibilities that minimizes the adverse effect of temperature rise such as change in phase, denaturation of proteins and change in sensory attributes of the product. The membranes remove unwanted components viz. microorganisms, drugs or sediments that have a negative impact on product quality, making the final product more attractive in texture and increasing its shelf life. The selectivity of membranes is very high due to the unique mechanisms of action such as ion exchange, solution diffusion, etc. The membranes are suitable to different types of plant design and expansion due to their compact design and need very low maintenance. The operations of the membranes are very simple, competitive and do not required any specialized knowledge to handle or operate them. To get the desired effect, it is sometimes necessary to use a combination of membranes rather than single membrane (Balannec et al., 2005; Vourch et al., 2005) and redesigning overall industrial production by the integration of various already developed membrane operations (Saxena et al., 2009).

CHARACTERISTICS OF MEMBRANE

Microfiltration (MF) is a membrane separation process similar to ultrafiltration (UF) but with even larger membrane pore size allowing particles in the range of 0.2 to 2 micrometers to pass through. The pressure used is generally lower than that of UF process. MF membranes are especially well suited for the separation of fine particles in the size range of 0.1 to 10.0 μm whereas UF membranes with 1 to 100 nm pore size were designed to provide high retention of proteins and other macromolecules (Van Reis et al., 2007). UF is a variety of membrane filtration in which hydrostatic pressure forces a liquid against a semi-permeable membrane. Suspended solids and solutes of high molecular weight are retained, while water and low molecular weight solutes pass through the membrane. It is a separation/fractionation process using a 10,000 MW cutoff, 40 psig, and temperatures of 50 to 60°C with polysulfone membranes. Nanofiltration (NF) is a type of reverse osmosis where the membrane has a slightly more open structure allowing monovalent ions to pass through the membrane and rejecting the divalent ions to a great extent. RO is a high pressure-driven membrane filtration process which is based on a very dense membrane. The Reverse osmosis (RO) membrane pore size is very small allowing only small amounts of very low molecular weight solutes to pass through the membranes. It is a concentration process using a 100 MWCO (molecular weight cutoff), 700 psig, temperature lower than 40°C with cellulose acetate membranes and 70–80°C with composite membranes. MWCO is the equivalent molecular weight of the smallest protein that would exhibit above 90% rejection. Diafiltration (DF) is a specialized type of ultrafiltration process in which the retentate is diluted with water and re-ultrafiltered, to reduce the concentration of soluble permeate components and to further increase the concentration of retained components.

USE OF MEMBRANE IN DAIRY INDUSTRY

In the modern dairy processing, membranes play a major role in clarification of the milk, increase the concentration of the selected components as well as separation of the specific valuable components from milk or dairy by-products etc. Membrane separation technology seems a logical choice for the fractionation of milk, because many milk components can be separated on size (Figure 2) (Brans et al., 2004). Membranes are already well established in the processing of whey and are gaining popularity in other dairy applications (Daufin et al., 2001). The membrane technology improves the economics of dairy by reducing the cost of production as well generating new revenue resources (Siebert et al., 2001). Membrane technology proves a suitable and economical alternative to many important processing stage of milk in dairy industry such as centrifugation, bactofugation, evaporation, demineralization of whey, etc (Pouliot, 2008). The CO2-aided cold MF process has the potential to become economically attractive to the dairy industry, with direct benefits for the quality and shelf life of dairy products (Fristch and Moraru, 2008). Initial reports have indicated that MF will reject fat and microbes while allowing other milk constituents to pass through the membrane, resulting in (theoretically) fat-free, bacteria-free milk (Piot et al., 1987). The membrane area of RO has stabilized around 60,000 m2, mainly for whey concentration. MF is developing due to its capability to retain, partly or totally, particles (microorganisms, casein micelles, fat globules), and NF has a large field of applications due to its intermediate selectivity (200 to 1,000 Da) between UF and RO (demineralization, de-ionization, purification) in particular for whey protein valorization (Saxena et al., 2009).

APPLICATION OF MEMBRANES IN DIFFERENT FIELDS OF DAIRY TECHNOLOGY

Various types of membrane filters with different properties are available in market (Table 1) and commonly used in the dairy industry. Membranes have been applied in different fields of dairy technology including shelf life of milk, whey processing, cheese industry, milk protein processing, fractionation of milk fat and desalting or demineralization.

Application of membranes in extending shelf life of milk

Extended shelf life (ESL) milk products are products that have been treated in a manner to reduce the microbial count beyond normal pasteurization, packaged under extreme hygienic conditions, and have a prolonged shelf life under refrigerated conditions (Rysstad and Kolstad, 2006). Microfiltration constitutes an alternative to heat treatment to reduce the presence of bacteria and improve the microbiological safety of dairy products while preserving the taste (Pafylias et al., 1996). It is a non thermal method of removing bacteria and spores from milk, whey and cheese brine and extending shelf life without damaging sensory attributes (Meersohn, 1989). The significant reduction of mesophilic, Salmonellae and Listeria count have been reported upon using MF with 1.4 μm pore size (Madec et al., 1992). Cold MF could also minimize microbial fouling of the membrane and prevent the germination of thermophilic spores (Fristch and Moraru, 2008). Fristch and Moraru (2008) performed a study to analyse microbiological, chemical, and somatic cell count to evaluate the effect of MF on the composition of skim milk and found that permeate flux increased drastically when velocity was increased from 5 to 7 m/s.
By the suitable modifications in the membranes structure, design and composition, it is possible to make milk free from bacteria (Malmberg and Holms, 1988; Olesen and Jensen, 1989). ESL milk has been prepared by removing bacteria from milk by MF without causing any compositional change or negligible decrease in the total protein by 0.02 to 0.03% (Hoffmann et al., 2006). A thermal treatment or combination of heat treatment and membrane filtration are involved in the production of ESL milk (Lorenzen et al., 2011).
By adding a filtrate circulatory system in the concentrate circulatory system of membrane filters (better known as UTMP concept Uniform Transmembrane Pressure concept), up to 99.70% of the bacterial load in skim milk has been achieved by Alfa Laval (Olesen and Jensen, 1989). Tetra Alcross Bactocath of Alfa Laval removes the bacteria and spores from milk by separating milk into cream and skim milk and then separates the skim milk from bacteria and spores by microfiltration, while retaining all bacteria and spores in retentate which is about 0.5% of the original milk volume. The retentate is mixed with suitable amount of cream and mixed in filtered milk after pasteurizing it. As the heat treatment is given to a very small amount of milk, the organoleptic and sensory attributes of milk are retained. It extends the shelf life of milk by 12 to 45 d at 4°C (Olesen and Jensen, 1989; Puhan, 1992; Saboya and Maubois, 2000; Goff and Griffiths, 2006). The major hitch is that it does not remove all pathogenic bacteria from milk, thus still necessitate the heat treatment (Rosenberg, 1995).
The somatic cell counts (SCC) increase in the milk of lactating cows suffering from mastitis and thus severely affecting the composition and quality of milk (Sharma and Maiti, 2010; Sharma et al., 2011; Sharma et al., 2012a; Sharma et al., 2012b). This somatic cell count can be reduced up to 100% by the application of combined processes of MF (microfiltration) followed by HHT (high heat treatment) (Pedersen, 1992). Damerow (1989) reported the extension of shelf life of refrigerated milk from 12 d to 18 d at 8°C by the combined application of MF and HHT without compromising sensory attributes by reducing the number of psychrotrops. The MF process is more efficient in removing bacteria and spores than the bactofugation (Stack and Sillen, 1998). With the direct epifluorescent filter technique (DEFT) technology, keeping quality of milk can be judged in short time by concentrating the bacterial cells and their spores as well as somatic cells by membranes followed by quantification of these by epifluorescent microscopy (Pettifer, 1982).
Recently narrow pore sizes in smooth inert silicon nitride surface microsieves have been prepared by micro-machining technology to increase the selectivity and permeability to pass liquids at lower transmembrane pressure (Brans et al., 2004). The microsieves also reduce the fouling as well as microbial count significantly in milk (Van Rijn and Kromkamp, 2001).

Application of membranes in whey processing

Whey is a dairy by-product which is obtained during the preparation of milk products viz. cheese, paneer and casein. Paneer is an Indian dairy product similar to soft cheese prepared by coagulating casein with citric acid, lactic acid or tartaric acid (Kumar et al., 2011a; Kumar et al., 2008). Whey is simply drained in most of the cases in developing countries. This causes huge loss of valuable nutrients as well as creating environmental hazards. The separation or concentration of whey nutrients by traditional method is cumbersome and time consuming. By application of different membrane filtration technology, the nutrients in whey are concentrated, fractionalized or purified into valuable products such as whey protein concentrate/isolates, α-lactalbumin, β-lactoglobulin, lactose and salts (Figure 3). Up to 60% more saving on fuel has been reported in whey concentration by applying RO over the traditional evaporation methods. By application of UF and DF, the protein content of the whey protein concentrate can be increased by 35 to 85% of the total solids whereas by removing bacteria and fat by passing whey through MF, the protein content of whey protein isolates can be increased to 90% of the total solid content (Lipnizki, 2010).
The membrane separation of bacteria and spores also leads to production of high quality whey protein concentrate (WPC) and whey protein isolates (WPI) with inherent functional properties from whey (Lipnizki, 2010) as it avoid the denaturation of whey or serum proteins. These whey proteins are used in food industry for their high biological value as well as their ability to improve the functional properties (emulsifying, foaming and gelling) of the food products (Harper, 1992). The removal of as much lipids as possible from whey by efficient membrane function produces whey protein concentrate with good keeping quality (Harper, 1992). At present the WPC are prepared on industrial scales by using UF, however fouling of membranes still remains a concern. UF and RO have application in production of concentrated whey and whey protein concentrates (Sienkiewicz and Riedel, 1990).
The development of off-flavour in these whey products due to the impurities of lipids causing rancidity remain the major concern (Morr and Ha, 1993). A number of studies have suggested the removal of residual fat from whey by thermocalcic precipitation under which phospholipids are aggregated by calcium under heat treatment for 8 min at 50°C followed by removal of the precipitates by MF and UF (Fauquant et al., 1985; Harper, 1992; Gesan et al., 1995). The advances in MF make it easier to direct removal of lipoproteins by separating the transmembrane pressure from the inlet pressure limiting the fouling.
With the use of membrane technology, it is possible to concentrate and separate whey proteins in their un-denatured form with high functional property in native whey as compared to traditional sweet cheese whey (Maubois, 2002). Native whey protein concentrates (NWPC) and native whey protein isolates (NWPI) are produced by UF concentrating the native whey (Maubois et al., 2001), showing excellent gelling, foaming and reconstituability on drying (Ostergaard, 2003). At present, these native whey proteins are utilized extensively in human nutrition as an integral component of weight balancing products (Burton-Freeman, 2008) and in baby foods due to lower risk of hyperthreoninemia due to lack of glycomacropeptides which in turn are rich in threonine (Rigo et al., 2001). The individual whey protein can be concentrated or fractionated by application of membrane technology. This facilitates the production of WPC with the enrichment of specific proteins or with single proteins. The composition of whey proteins differ very little from that of membrane permeates obtained during concentration of the casein (Brans et al., 2004). Doyen et al. (1996) reported that the main concern during the preparation of whey protein concentrate is fouling as membranes with different permeability have the comparable flux due to the pressure independent flux regime. A typical whey micro-filtration process may run in long cycles of about 24 h, which offer great potential for the formation of bacterial biofilms leading to reduced membrane performances.

Application of membranes in Cheese industry

Membrane filtration technology has number of applications in cheese industry such as improving the nutritive quality, better compositional control and yield of cheese by increasing the total solid content, utilization of whey during preparation of cheese, comparatively reducing the requirement of rennet and starter culture. Concentrating the milk prior to cheese making opens a new arena in cheese industry thereby reducing the cost as well as hasten the whole procedure of cheese making (Henning et al., 2006). The quality of cheese brine is maintained easily by membrane filters of pore size of 100 μm to removing bacteria and spores as well as other extraneous matters and maintaining the chemical balance of brine which results in production of high quality cheese with superior flavour and shelf life (Ottosen and Konigsfeldt, 1989).
The UF and MF are most commonly used in the cheese industry.

Use of UF in cheese making:

UF technology in cheese processing is highly remunerative by concentrating milk by a factor of 1.2 to 2.0 times (Rosenberg, 1995) and increase in the casein: protein ratio (Guinee et al., 1995; Guinee et al., 2006; Johnson and Lucey, 2006) leading to fewer requirements of processing equipments, better compositional and quality control as well as improving the yield of cheese. A 13 to 14% saving of skim milk has been reported during preparation of quarg cheese with the application of UF process as compared with traditional process (Pedersen and Ottosen, 1992). By removing the water during concentration of milk by the application of membrane filtration technology, it is possible to make cheese without whey, thus do not require the use of cheese vat and avoid cumbersome processing steps of removal and draining of whey. However, some workers reported the negative impact on the ripening of semi-hard and hard cheese due to increased whey content in cheese prepared by concentrated milk (Qvist, 1987). Lipnizki (2010) rightly called UF as complementary process of cheese making. With the application of UF, good quality fresh and brine cheese is obtained with higher yield (Pedersen and Ottosen, 1992; Puhan, 1992; Mistry and Maubois, 1993). Maubois et al. (1969) first patented the procedure of production of cheese on industrial basis from UF retentate by using MMV method (a process named after its inventors Maubois, Mocquot and Vassal) by concentrating the milk by 5 to 7 times and getting the high quality curd. The increase in the viscosity and buffering capacity of such cheese milk needs certain procedural modifications in the process of cheese making (Pouliot, 2008). UF of milk is done to save cost during preparation of semi-hard and hard cheese by increasing the salt and whey protein concentration but it causes compromised sensory and functional properties (Mistry and Maubois, 1993) with slower ripening rate due to decreased proteolysis caused by reduction chymosin and rennin action and presence of more whey proteins (Neocleous et al., 2002). Some reports mentioned that UF have not given good results in making of fresh cheese from acidified curd as it is difficult to process high acidic milk by these traditional membranes. Increasing the pH before fermentation results in poor sensory attributes with enhanced proteolysis and mineral contents. With the introduction of advanced ceramic and polysulfone membranes, it is possible to apply UF to acidic milk with pH 4.4 to 4.6 in the production of better quality of fresh cheese (Jelen and Renz-Schauen, 1989).
Based on the concentration factors and increase in the protein content, there are three different types of retentate obtained in the UF viz. low concentrated retentate (LCR), medium or intermediate concentrated retentate (MCR) and liquid pre-cheese (LPC) (Rosenberg, 1995; Henning et al., 2006) (Table 2).

Use of MF in cheese making:

The MF casein concentrated milk is very suitable for various cheese preparations due to its superior microbial quality achieved after removing bacteria and spores from milk, as well as optimization of the different major milk components. The MF pre-treatment of cheese milk improves the firmness of curd, accelerate ripening (Pierre et al., 1992; Caron et al., 1997; Maubois, 2002), reduce the amount of additives e.g. CaCl2 (Schafroth et al., 2005) and facilitates heating at higher temperature. Further the UHT milk need higher amount of rennet for coagulation. By application of UF, UHT milk is coagulated with lesser amount of rennet by compensating the hindrance to coagulation arising from the formation of complexes between k-casein and β-lactoglobulin by reduction of the zeta potential of the casein micelle (Mistry and Maubois, 1993).
The MF has future possibilities in standardization of protein in cheese milk and fortification with casein micelle powder (Mistry and Maubois, 1993). The MF followed to HTT (high temperature treatment) is more efficient than single stage bactofugation in terms of microbial quality. But this treatment of MF followed by HTT modifies rennet coagulation and increases the water holding capacity, necessitating adjustments in the parameters during cheese preparation (Pedersen and Ottosen, 1992).

Application of membranes in milk protein processing

Milk proteins especially caseins play important role in white turbid appearance and viscosity of milk. By application of ultra filtration, the level of protein content in milk is adjusted without adding any extraneous protein source by removing the water. This causes the maintenance of the composition, nutritive value, physico-chemical properties and sensory attributes of the milk irrespective to the variation caused by the genetic as well as environmental factors (Puhan, 1992). Adding of 1% ultra filtered protein enriched milk in skim milk has improved the viscosity and sensory attributes to similar to full cream milk (Quinones et al., 1997). The milk protein concentrate (MPC) containing 50 to 58% proteins of good functionality are prepared by application of MF, UF and diafiltration (DF) technologies either alone or in combinations.

Fractionalization of milk protein:

Separating out the various milk components of different sizes from milk by applying membrane technology (Figure 3) will transform dairy industry into very efficient and profitable enterprises. Jimenez-Lopez et al. (2008) described membrane pore size homogeneity, concentration polarization phenomena and membranes fouling as main factors determining the fractionalization of milk components. The milk protein concentrates (with 50 to 85% protein in the products) and milk concentrates (with more than 85% protein in the products) are increasingly prepared by using MF (Novak, 1992). The composition, heat stability, rheological and textural properties of these products depend upon the type of membranes used and prevailing processing conditions such as, temperature, pH, time of processing. The judicious use of these factors should be selected based on the ultimate use of the MPC (milk protein concentrate) and MP (milk protein) (Novak, 1992; Hallstrom and Dejmek, 1988). Novak (1992) suggested UF processing at 50 to 60°C with high flow rate to minimize the whey protein denaturation for desired rheological properties.
A lot of work has performed to recover valuable proteinacious components from dairy waste streams (Chakravorty and Singh, 1990). Dairy proteins are valuable products and used as high-value food additives, neutriceutical and therapeutics. The milk protein can be recovered by using MF, UF and NF processes. MF of milk separates the casein micelles and whey proteins (Maubois et al., 1987). The various milk proteins such a casein and serum or whey proteins are separated in a simple and economic method by applying membrane filters of 0.2 μm pore size at constant TMP, without the need of application of heat and chemicals.

Casein:

Membrane technology has revolutionized the casein industry. Application of different membrane types with desired pore size either alone or in combination with enzymatic action, chromatography lead to the concentration, fractionalization and purification of milk proteins. The physico-chemical properties of casein in relation to membranes largely depend upon the ionic strength as well as temperature (Mulvihill, 1992). At suitable ionic strength, it is possible to concentrate and fractionate casein as β-casein at 5°C, skim milk at 4°C and pH 4.2 to 4.6 (Famelart et al., 1989) using MF and UF separating β-casein in permeates and α and κ-casein in retentate (Murphy and Fox, 1990). The native casein can be concentrated in retentate by passing the skim milk into MF with 0.2μm pore size (Fauquant et al., 1985; Maubois and Ollivier, 1992). Upto 90% casein concentration is possible by DF and it can be used for industrial, pharmaceutical as well as edible purposes (Maubois and Ollivier, 1992). The concentrated casein and native casein micelles can be prepared through ceramic, ceraflow, membralox membrane with different flux (Pouliot et al., 1996; Vadi and Rizvi, 2001; Van Rijn and Kromkamp, 2001; Brans et al., 2004). The significant improvement was recorded in flux with 65 kPa transmembrane pressure having flow velocity of 12.5 metre/second (Krstic et al., 2002).
Papadatos et al. (2003) found that although there was higher profit in the production of cheddar and mozzarella cheese by MF milk in North America but the profit changed little with the increase in concentration of casein from 2 to 3 times. The fouling is major concern than selectivity during the concentration of casein in milk as some whey proteins are there in casein and vice versa and thus affecting the yield of cheese as well as whey concentrates (Brans et al., 2004). Use of membrane process accompanied with other advance technology as liquid chromatography, leads to purification of casein derived bioactive peptides showing morphine-mimicking, cardiovascular and immunostimulating activities (Maubois and Ollivier, 1992; Mulvihill, 1992).

Fractionalization of whey protein:

Whey proteins are obtained by concentrating and purification from whey. Govindasamy-Lucey et al. (2007) and Lawrence et al. (2008) separated the whey protein from skimmed milk by polymeric microfiltration in permeate flux. Mass flux form of permeated whey protein with permeates flux, mainly determine the whey protein concentration and fractionalization (Gauthier et al., 2006). With the advancement of newer technology in membrane process, it is possible to recover growth factor from whey (Gauthier et al., 2006). Attempts have been made to tap the growing market of health foods by separating immunoglobulins and growth factors from colostrum by applying MF and UF with suitable modifications (Regester et al., 2003; Piot et al., 2004).
The β-lactoglobulin is separated by the membrane process followed by heat treatment (Maubois et al., 1987; Pearce, 1987). The β lactoglobulin can be fractionized from defatted whey proteins by using MF and centrifugation followed by purification by UF with electrodialysis (ED) or DF. β-lactoglobulin is purified by diafiltration of supernatant (Maubois et al., 1987), while immunoglobulins are separated from whey protein concentrates by using membrane technology (Scott and Lucas, 1989). The α-lactalbumin is separated and purified by applying UF on solubilised MF retentate at neutral pH (Rosenberg, 1995). With the introduction of inorganic membranes with polyvinylimidazole derivates, the pure α-lactalbumin can be obtained in filtrate but the fouling proves major constraint (Chaufer et al., 1991; Chen and Wang, 1991). The whey proteins can be separated from WPI by applying UF/DF with more than 99% purity (Mailliart and Ribadeau-Dumas, 1988). The use of hydrophilic cellulose membrane made it possible to separate low molecular weight compounds from high molecular weight compounds (Mehara and Donnely, 1993). Lactoferrin and lactoperoxidase are recovered from defatted WPC on industrial scale by using ion-exchange chromatography (Perraudin, 1991).

Application of membranes in milk fat processing

Traditionally, cream is separated from whole milk by energy intensive centrifugation in which lighter fat globules moves towards the centre and heavier skim milk move towards periphery under the centrifugal force. The cream separation is also possible by energy saving membranes technology producing skim milk with good storage quality and improved sensory attributes of cream without causing any damage to fat globular membranes. Goudedranche et al. (2000) reported the fractionation of fat globules by application of membranes of 2 μm size. The size of fat globules have profound impact on textural and sensory attributes as the cream with smaller fat globules have fine texture and improved flavour than cream with large fat globules.

Role of membranes in desalting or demineralization

The removal of minerals from whey increases its value (Kelly et al., 1991). The cheese whey is rich in salt and acids and the reduction or demineralization of whey is essential before its use and to alleviate the environmental hazards. The demineralization is done by electrodialysis and ion exchange process (Greiter et al., 2002) in the dairy industry to get up to 60% reduction of minerals (Kelly et al., 1991). The efficiency of electrodialysis can be increased by pre-concentrating up to 20% dry matter by RO or evaporation. By ion exchange, desalting of whey is done by passing it over ion exchange column and the rate of removal of ions depends upon the resin used in the column as well as the type of ions. The need of lots of water and chemicals for regeneration of resins is the major limitations of this technology.
The NF membranes with molecular weight cutoff (MWCO) ranging between 200 to 1,000 Daltons are best suited for demineralization of whey as these membranes are permeable to salt and monovalent ions but impermeable to organic compounds. The carboxyl group of organic compounds bound to these membranes under prevailing acidic conditions. This technology simultaneously demineralises whey at the time of concentrating, helping in savings in term of cost, time and water disposal (Kelly et al., 1991). The NF is more economical than electrodialysis and a method of choice for partial desalting of whey. NF membranes are highly permeable to water and monovalent ions. The mineral contents of the whey is reduced by 35% and ash content by 3 to 4 times in addition to increase concentration of whey by applying nanofiltration (NF), making it suitable for the people having cardiovascular diseases. The mineral content of whey is further reduced by 45% by applying DF (Kelly et al., 1991; Lipnizki, 2010). The reduction of mineral content in whey, liquor and brines on industrial scale can be done mainly by NF (Kelly et al., 1991; Van der Horst et al., 1995; Horton, 1997a; b; Horton, 1998). Daifiltration also causes the removal of ions to a greater extent.

Other applications

The use of different membranes accompanied with suitable heat treatments leads to the development of several dairy products with unique characteristics as better compositional control, binding, texture, juiciness, etc. With the help of membrane technology, several novel products are introduced in market as lactose free milk for lactose intolerant people, low calcium milk, non fat yoghurt, high protein low lactose ice cream, protein fortified low fat milk, whey based beverages, etc. By applying RO (reverse osmosis), milk is condensed by removing about 70% of its water and retaining all other components of milk without undergoing any thermal processing. During preparation of fermented dairy milk such as cheese, yoghurt and curd, the protein and total solids of standardized UF milk show better textural and nutritional properties than those of prepared by either adding milk powder or evaporated milk (Puhan, 1992). It is easier to control the textural and compositional properties of milk by membrane filtration technology, but it necessitates better attention to the selection of starter and incubation/ripening conditions such as temperature, time and pH (Rosenberg, 1995: Lipnizki, 2010). Rosenberg (1995) noted that such changes is due to the increasing content of lactose and minerals, higher osmotic pressure, change in the pH, change in ionic strength as well accumulation of some inhibitory compounds in the UF treated milk.
The transport cost of milk is reduced by membrane technology by pre-concentrating it, removing the water and lactose or dewatering it at farm level and thus decreasing the volume of transported milk without damaging its sensory attributes (Rattray and Jelen, 1996). RO of milk results in permeate containing protein and minerals whereas UF of milk produces permeate consisting of water and lactose. Membrane technology is used to separate κ-casein-glycomacropeptide (GMP), which have pharmaceutical uses in controlling the adhesion of E. coli cells to the intestine walls, protects against influenza and prevents adhesion of tartar to teeth (Maubois and Ollivier, 1992).

FOULING OF MEMBRANES

Membranes are having some limitations such as fouling of membranes due to blockage of membrane pores, adsorption of particles on the pores, deposition of protein and minerals, cake formation and depth fouling (James and Chen, 2003; Popovic et al., 2010; Anand et al., 2012), and bacterial biofilms (Kumar and Anand, 1998; Tang et al., 2009). The fouling is caused by the accumulation of particles, bacteria and sediments present in milk leading to remarkable loss in the efficiency of membranes. The fouling of membrane remains the major concern in dairy industry (Gesan et al., 1995; Makardij et al., 1999). The fouling of membranes is mainly affected by several factors such as backpulsing, crossflushing, backwashing, particle size, membrane surface chemistry and ionic strength (Huimin et al., 2001).
This major issue of fouling in membranes can be trounced by regular cleaning of membranes at appropriate time intervals, use of low fouling membranes, membrane modules with suitable channel heights, by applying high pressure, application of electric potential, ultrasound waves, microturbulence, ceramic membranes, uniform transmembrane pressure (UTP), vibrating and rotating disc modules, use of turbulent flow of liquids (Vishwanathan and Ben, 1989; Saboya and Maubois, 2000; Duriyabunleng et al., 2001; Ding et al., 2002; Wakeman and Williams, 2002) and high frequency back pulsing (Levesley and Hoare, 1999).

FUTURE TRENDS

There is need for progressive development of innovative applications based on the technique. Currently, the membranes for dairy processes have rather a low capacity owing to strong flux decline by fouling and processes are energy demanding because of the high cross-flow velocity that is required to control fouling. Furthermore, methods to control fouling have increased the complexity in equipments and operation. Besides fouling, selectivity is an important issue for membrane fractionation of milk. Therefore, we need innovative techniques for the development of cheap, easily available, superior and long lasting membranes. Consumers are looking for products with increased freshness and higher quality and the retailers require products with extended shelf life and the demands of both can be fulfilled by the use of the membrane technology.

CONCLUSION

Introduction of membrane technology into dairy science witnesses phenomena of mutual benefit for membranes as well as for dairy industry. The marked improvement in the nutritive quality and sensory attributes of the existing dairy products with higher yields in addition to development of several innovative dairy products became possible by the application of membrane technology. Continuing the efforts for the development of superior membranes will further expand the role of membranes in dairy processing.

ACKNOWLEDGMENTS

This work was supported by the research grant from the Chungbong Academic Research Fund of Jeju National University, Jeju, Korea in 2010.

Figure 1
Milestones in the development of membrane technologies for protein separation/purification (Adopted from Saxena et al., 2009).
ajas-26-9-1347-17f1.gif
Figure 2
Components in milk: size indication and membrane processes. MF = Microfiltration, UF = Ultrafiltration, NF = Nanofiltration, RO = Reverse osmosis (Adopted from: Daufin et al., 2001).
ajas-26-9-1347-17f2.gif
Figure 3
Diagrammatic representation of use of membrane in whey processing.
ajas-26-9-1347-17f3.gif
Table 1
Commonly used membrane techniques in dairy industry
Type Pore size Molecular weight cut off Pressure and principle Compounds in retentate Application in dairy industry
Microfiltration 0.2–2 μm >200 kDa Low pressure (below 2 bar) driven membrane process Low retentate, separation of protein, bacteria and other particulates
  • - Skim milk and cheese

  • - Dextrose clarification

  • - Bacteria removal

Ultrafiltration 1–500 μm 1–200 kDa Medium pressure (1–10 bar) pressure driven process to overcome the viscosity Large retentate with casein micelles, fat globules, colloidal minerals, bacteria and somatic cells
  • - Standardization of milk, reduction of calcium and lactose

  • - Protein, whey, milk concentration

Nanofiltration 0.5–2 nm 300–1,000 Da Medium to high pressure (5–40 bar), mass transfer phenomena by size exclusion and electrostatic interactions Low productivity, separate monovalents salt and water Desalting of whey, lactose free milk, volume reduction
Reverse osmosis or hyperfiltration No pores 100 Da High pressure, 10–100 bar Based on the principle of solubility, low productivity volume reduction, recovery of total solids and water
Table 2
Role of UF in concentrating cheese milk
Retentate Concentration factor Types of cheese Remark
Low concentrated retentate (LCR) 1.2–2: 1 Cheddar, brick, cottage cheese, colby, mozarella, edam, saint paulin, quag 4.5–5% more protein in cheese, Increase yield, efficient utilization of cheese vat, good compositional control
Medium/concentrated retentate (MCR) 2–6: 1 Cheddar, feta, havarti, gouda, and blue cheese 6–8% more yield, need special cheese making equipment
Liquid pre cheese (LPC) Same as of cheese curd Feta, mozzarella, quarg, camembert, ricotta, cream cheese, mascarpone and saint mauri Very economical, cheese vat not required, minimum whey drainage

REFERENCES

Anand A, Hassan A, Avadhanula M. 2012. The effects of biofilms formed on whey reverse osmosis membranes on the microbial quality of the concentrated product. Int J Dairy Technol 65:451–455.
crossref
Balannec B, Vourch M, Rabiller-Baudry M, Chaufer B. 2005. Comparative study of different nanofiltration and reverse osmosis membranes for dairy effluent treatment by dead-end filtration. Sep Purif Technol 42:195–200.
crossref
Brans G, Schroen CGPH, Van der Sman RGM, Boom RM. 2004. Membrane fractionation of milk: state of the art and challenges. J Memb Sci 243:263–272.
crossref
Burton-Freeman BM. 2008. Glycomacropeptide (GMP) is not critical to whey-induced satiety, but may have a unique role in energy intake regulation through cholecystokinin (CCK). Physiol Behav 93:379–387.
crossref pmid
Caron A, Saint Gelais D, Pouliot Y. 1997. Coagulation of milk enriched with ultrafiltered or diafiltered microfiltered milk retentate powders. Int Dairy J 7:445–451.
crossref
Chakravorty B, Singh DP. 1990. Concentration and purification of gelatin liquor by ultrafiltration. Desalination 78:279–286.
crossref
Chaufer B, Rollin M, Sebille B. 1991. High-performance liquid chromatography and ultraÞltration of whey proteins with inorganic porous materials coated with polyvinylimidazole derivatives. J. Chromatogr 548:215–228.
crossref
Chen JP, Wang CH. 1991. Microfiltration affinity purification of lactoferrin and immunoglobulin G from cheese whey. J Food Sci 56:701–706.
crossref
Childress AE, Elimelech M. 2000. Relating nanofiltration membrane performance to membrane charge (Electrokinetic) characteristics. Environ Sci Technol 34:3710–3716.
crossref
Damerow G. 1989. Die anwendung der mikrofiltration fur die konsummilch, kessel-milch, Molke. Dtsch Molkerei Zeitung 110:1602–1608.

Daufin G, Escudier JP, Carrere H, Berot S, Fillaudeau L, Decloux M. 2001. Recent and emerging applications of membrane processes in the food and dairy industry. Trans ICheme 79:89–102.
crossref
Ding L, Al-Akoum O, Abraham A, Jaffrin MY. 2002. Milk protein concentration by ultrafiltration with rotating disk modules. Desalination 144:307–311.
crossref
Doyen W, Adriansens W, Molenberghs B, Leysen R. 1996. A comparison between polysulfone, zirconia and organo-mineral membranes for use in ultrafiltration. J Memb Sci 113:247–258.
crossref
Duriyabunleng H, Petmunee J, Muangnapoh C. 2001. Effects of the ultrasonic waves on microfiltration in plate and frame module. J Chem Eng Jpn 34:985–989.
crossref
Famelart MH, Hardy C, Brule G. 1989. Optimisation of the preparation of p-casein-enriched solution. Lait 69:47–57.
crossref
Fauquant J, Vieco E, Brule G, Maubois JL. 1985. Clarification of sweet cheese whey by thermocalcic aggregation of residual fat. Lai 65:1–20.
crossref
Fauquant J, Maubois JL, Pierre A. 1988. Microfiltration du lait sur membrane minérale. Tech Laitiere Mark 1028:21–23.

Fritsch J, Moraru CI. 2008. Development and optimization of a carbon dioxide-aided cold microfiltration process for the physical removal of microorganisms and somatic cells from skim milk. J Dairy Sci 91:3744–3760.
crossref pmid
Gauthier SF, Pouliot Y, Maubois JL. 2006. Growth factors from bovine milk and colostrum: composition, extraction and biological activities. Lait 86:99–125.
crossref
Gesan G, Daufin G, Merin U, Labbe JP, Quemerais A. 1995. Microfiltration performance: Physiochemical aspects of whey pre-treatment. J Dairy Res 62:269–279.
crossref
Goff HD, Griffiths MW. 2006. Major advances in fresh milk and milk products: Fluid milk products and dairy desserts. J Dairy Sci 89:1163–1173.
crossref pmid
Goudedranche H, Fauquant JJ, Maubois JL. 2000. Fractionation of globular milk fat by membrane microfiltration. Lait 80:93–98.
crossref
Govindasamy-Lucey S, Jaeggi JJ, Johnson ME, Wang T, Lucey JA. 2007. Use of cold microfiltration retentates produced with polymeric membranes for standardization of milks for manufacture of pizza cheese. J Dairy Sci 90:4552–4568.
crossref pmid
Greiter M, Novalin S, Wendland M, Kulbe KD, Fischer J. 2002. Desalination of whey by electrodialysis and ion exchange resins: analysis of both processes with regard to sustainability by calculating their cumulative energy demand. J Memb Sci 210:91–102.
crossref
Guinee TP, Kennedy BT, Kelly PM. 2006. Effect of milk protein standardization using different methods on the composition and yields of cheddar cheese. J Dairy Sci 89:468–482.
crossref pmid
Guinee TP, Pudja PD, Reville WJ, Harrington D, Mulholland OE, Cotter M, Cogan TM. 1995. Composition, microstructure and maturation of semi-hard cheese from high protein ultrafiltered milk retentates with different levels of denatured whey protein. Int Dairy J 5:543–568.
crossref
Hallstrom M, Dejmek P. 1988. Rheological properties of ultrafiltered skim milk. I. Effects of pH, temperature and heat pretreatment. Milchwissenschaft 43:31–34.

Harper WJ. 1992. New applications of membrane processes- In IDF Spl. Iss. 9201. Brussels, Belgium: p. 77–108.

Henning DR, Baer RJ, Hassan AN, Dave R. 2006. Major advances in concentrated and dry milk products, cheese and milk fat-based concepts. J Dairy Sci 89:1179–1188.
crossref pmid
Hoffmann W, Kiesner C, Clawinradecker I, Martin D, Einhoff K, Lorenzen PC, Meisel H, Hammer P, Suhren G, Teufel P. 2006. Processing of extended shelf life milk using microfiltration. Int J Dairy Technol 59:229–235.
crossref
Horton BS. 1997a. Whatever happened to the ultrafiltration of milk? Aust J Dairy Technol 52:47–49.

Horton BS. 1997b. Water, chemical and brine recycle or reuse-Applying membrane processes. Aust J Dairy Technol 52:68–70.

Horton BS. 1998. The whey processing industry-into the 21st century. In: Whey. IDF Bulletin. 9804Brussels, Belgium: p. 12–25.

Huimin M, Hakim LF, Bowman CN, Davis RH. 2001. Factors affecting membrane fouling reduction by surface modification and backpulsing. J Memb Sci 189:255–270.
crossref
James BJ, Jing Chen YXD. 2003. Membrane fouling during filtration of milk-a microstructural study. J Food Eng 60:431–437.
crossref
Jelen P, Renz-Schauen A. 1989. Quarg manufacturing innovations and their effects on quality, nutritive value, and consumer acceptance. Food Technol 43:74–81.

Jimenez-Lopez AJE, Leconte N, Dehainault O, Geneste C, Fromont L, Gesan-Guiziou G. 2008. Role of milk constituents on critical conditions and deposit structure in skim milk microfiltration (0.1 μm). Sep Purif Technol 61:33–43.
crossref
Johnson ME, Lucey JA. 2006. Major technological advances and trends in cheese. J Dairy Sci 89:1174–1178.
crossref pmid
Kelly PM, Horton BS, Burling H. 1991. Partial demineralization of whey by nanofiltration. New applications of membrane processes. IDF Bulletin 9201. Brussels, Belgium: p. 130–140.

Krstic DM, Tekic MN, Caric MD, Milanovic DS. 2002. The effect of turbulence promoter on cross-flow microfiltration of skim milk. J Memb Sci 208:303–314.
crossref
Kumar CG, Anand SK. 1998. Significance of microbial biofilms in food industry: a review. Int J Food Microbiol 42:9–27.
crossref pmid
Kumar S, Rai DC. 2010. Effect of antioxidants and paraffin wax on the physico-chemical properties of aerobically packaged buffalo milk paneer at refrigeration temperature. Milchwissenschaft 65:388–393.

Kumar S, Rai DC, Verma DN. 2008. Effect of different levels of lactic acid on the physico-chemical and sensory attributes of buffalo milk paneer. Indian J Anim Res 42:205–208.

Kumar S, Rai DC, Niranjan K, Bhat ZF. 2011a. Paneer-an Indian soft cheese variant : a review. J. Food Sci. Technol 10.1007/s13197-011-0567-x
crossref pmid pmc
Kumar S, Bhat ZF, Kumar P. 2011b. Effect of apple pulp and Celosia argentia on the quality of characteristics of Shrikhand. Am J Food Technol 6:817–826.
crossref
Lawrence ND, Kentish SE, OConnor AJ, Barber AR, Stevens GW. 2008. Microfiltration of skim milk using polymeric membranes for casein concentrate manufacture. Sep Purif Technol 60:237–244.
crossref
Levesley JA, Hoare M. 1999. The effect of high frequency back flushing on the microfiltration of yeast homogenate suspensions for the recovery of soluble proteins. J Memb Sci 158:29–39.
crossref
Lipnizki F. 2010. Cross-flow membrane applications in the food industry. Membrane Technology, Vol. 3: Membranes for Food Applications. Peinemann Klaus-Viktor, Nunes Suzana Pereira, Giorno Lidietta, editorsWILEY-VCH Verlag GmbH and Co. KGaA; Weinheim:
crossref
Lorenzen PC, Decker IC, Einhoff K, Hammer P, Hartmann R, Hoffmann W, Martin D, Molkentin J, Walte HG, Devrese M. 2011. A survey of the quality of extended shelf life (ESL) milk in relation to HTST and UHT milk. Int J Dairy Technol 64:166–178.
crossref
Madec MN, Mejean S, Maubois JL. 1992. Retention of Listeria and Salmonella cells contaminating skim milk by tangential membrane microfiltration (Bactocatch process). Lait 72:327–332.
crossref
Mailliart P, Ribadeau-Dumas B. 1988. Preparation of β-lactoglobulin and p-lactoglobulin-free proteins from whey retentate by NaCl salting out at low pH. J Food Sci 53:743–747.
crossref
Makardij A, Chen XD, Farid MM. 1999. Microfiltration and ultrafiltration of milk: some aspects of fouling and cleaning. Trans IChemE 77:107–113.
crossref
Malmberg R, Holms S. 1988. Producing low-bacteria milk by microfiltration. N Eur Food Dairy J 54:30–32.

Maubois JL. 2002. Membrane microfiltration: a tool for a new approach in dairy technology. Aust J Dairy Technol 57:92–96.

Maubois JL, Ollivier G. 1992. New Applications of Membrane Processes. IDF Spl. Iss. 9201Brussels, Belgium: p. 15–22.

Maubois JL, Pierre A, Fauquant J, Piot M. 1987. Industrial fractionation of the main whey proteins. IDF Bulletin 212Brussels, Belgium: p. 154–159.

Maubois JL, Mocquot G, Vassal L. 1969. A method for processing milk and dairy products. French Patent FR 2 052121

Maubois JL, Fauquant J, Famelart MH, Caussin F. 2001. Milk microfiltrate a convenient starting material for fractionation of whey proteins and derivatives. In : Proc. 3rd Int Whey Conf. The importance of whey and whey components in food and nutrition; München. Germany. p. 59–72.

Meersohn M. 1989. Nitrate-free cheese making with the Bactocatch. North Eur Food Dairy J 55:108–113.

Mehara RK, Donnely WJ. 1993. Fractionation of whey protein components through a large pore size, hydrophilic, cellulosic membrane. J Dairy Res 60:89–97.
crossref
Mistry VV, Maubois JL. 1993. Application of membrane separation technology to cheese production. Cheese: Chemistry, Physics and Microbiology. Fox PF, editorChapman & Hall; London: p. 493–522.
crossref
Morr CV, Ha EYW. 1993. Whey protein concentratesand isolates: processing and functional properties. Crit Rev Food Sci Nutr 33:431–476.
crossref pmid
Mulvihill DM. 1992. Production, functional properties and utilization of milk protein products. Advanced Dairy Chemistry. I:Fox PF, editorChapman and Hall; p. 369–404.

Murphy JM, Fox PF. 1990. Fractionation of sodium caseinate by ultrafiltration. Food Chem 39:27–38.
crossref
Neocleous M, Barbano DM, Rudan MA. 2002. Impact of low concentration factor microfiltration on the composition and aging of Cheddar cheese. J Dairy Sci 85:2425–2437.
crossref pmid
Novak A. 1992. New applications of membrane processes. IDF Spl Iss 9201Brussels, Belgium: p. 51–66.

Olesen N, Jensen F. 1989. Microfiltration. The influence of operating parameters on the process. Milchwissenschaft 44:476–479.

Ostergaard B. 2003. Adding value to whey by Pro-Frac. Eur Dairy Mag 8:20–22.

Ottosen N, Konigsfeldt P. 1999. Microfiltration of cheese brine. Preliminary, APV Nordic, Membrane Filtration, SilkeborgDenmark:

Pafylias I, Cheryan M, Mehaiab MA, Saglam N. 1996. Microfiltration of milk with ceramic membranes. Food Res Intl 29:141–146.
crossref
Papadatos A, Neocleous M, Berger AM, Barbano DM. 2003. Economic feasibility evaluation of microfiltration of milk prior to cheesemaking. J Dairy Sci 86:1564–1577.
crossref pmid
Pearce RJ. 1987. Fractionation of whey proteins. Aust J Dairy Technol 42:75–78.

Pedersen PJ. 1992. New applications of membrane processes. IDF Spl Iss-9201Brussels, Belgium: p. 33–50.

Pedersen PJ, Ottosen N. 1992. New Applications of Membrane Processes. IDF Spl Iss 9201Brussels, Belgium: p. 67–76.

Perraudin JP. 1991. Biologically active proteins. Recently acquired knowledge and separation technology. Lait 71:191–211.
crossref
Pettipher GL. 1982. Developments in assessing milk quality Use of membrane filtration for assessing the hygienic quality of milk and milk products. Int J Dairy Technol 35:59–63.
crossref
Pierre A, Fauquant J, Le Graet Y, Piot M, Maubois JL. 1992. Préparation de phosphocaseinate natif par microfiltration sur membrane. Lait 72:461–474.
crossref
Piot M, Vachot JC, Veaux M, Maubois JL, Brinkman GE. 1987. Encremage et epuration bacteri-enne du lait entier cru par microfiltration sur membrane en flux tangentiel. Tech Laitiere Marketing 1016:42–46.

Piot M, Fauquant J, Madec MN, Maubois JL. 2004. Preparation of serocolostrum by membrane microfiltration. Lait 84:333–341.
crossref
Piry A, Kühn W, Grein T, Tolkach A, Ripperger S, Kulozik U. 2008. Length dependency of flux and protein permeation in crossflow microfiltration of skimmed milk. J Memb Sci 325:887–894.
crossref
Popovic S, Djuric M, Milanovic S, Tekic MN, Lukic N. 2010. Application of an ultrasound field in chemical cleaning of ceramic tubular membrane fouled with whey proteins. J Food Eng 101:296–302.
crossref
Pouliot M, Pouliot Y, Britten M. 1996. On the conventional cross-flow microfiltration of skim milk for the production of native phosphocaseinate. Int Dairy J 6:105–111.
crossref
Pouliot Y. 2008. Membrane processes in dairy technology-From a simple idea to worldwide panacea. Int Dairy J 18:735–740.
crossref
Puhan Z. 1992. New applications of membrane processes. IDF Spl Iss 9201Brussels, Belgium: p. 23–32.

Quinones HJ, Barbano DM, Phillips LG. 1997. Influence of protein standardization by ultrafiltration on the viscosity, colour, and sensory properties of skim and 1% milk. J Dairy Sci 80:3142–3151.
crossref pmid
Qvist KB. 1987. Objective and sensory assessment of texture of danbo cheese made from milk concentrated 2-fold using ultrafiltration. 272, Beretning/Statens Mejeriforsøg, Hillerød, Denmark

Rattray W, Jelen P. 1996. Freezing point and sensory quality of skim milk as affected by addition of ultrafiltration permeates for protein standardization. Int Dairy J 6:569–579.
crossref
Regester GO, Belford DA, West RJ, Goddard C. 2003. Development of minor dairy components as therapeutic agents-Whey growth factor extract, a case study. Aust J Dairy Technol 58:104–106.

Rigo J, Boehm G, Georgi G, Jelinek J, Nyambugabo K, Sawatzki G, Studzinski F. 2001. An infant formula free of glycomacropeptide prevents hyperthreoninemia in formula-fed preterm infants. J Pediatr Gastroenterol Nutr 32:127–130.
crossref pmid
Rosenberg M. 1995. Current and future applications of membrane processes in the dairy industry. Trends Food Sci Technol 6:12–19.
crossref
Rysstad R, Kolstad J. 2006. Extended shelf life milk-advances in technology. Int J Dairy Technol 59:85–96.
crossref
Saboya LV, Maubois JL. 2000. Current developments of microfiltration technology in the dairy industry. Lait 80:541–553.
crossref
Saxena A, Tripathi BP, Kumar M, Shahi VK. 2009. Membrane-based techniques for the separation and purification of proteins: An overview. Adv Colloid Interface Sci 145:1–22.
crossref pmid
Schafroth K, Fragnière C, Bachmann HP. 2005. Herstellung von Käse aus microfiltrierter. konzentrierter Milch. Deutsche Milchwirtschaft 56:861–863.

Scott GH, Lucas DO. 1989. Immunologically active whey fraction and recovery process. US. Patent 4,834,874

Sharma N, Maiti SK. 2010. Incidence, etiology and antibiogram of sub clinical mastitis in cows in durg, Chhattisgarh. Ind J Vet Res 19:45–54.

Sharma N, Srivastava AK, Bacic G, Jeong DK, Sharma RK. 2012b. Epidemiology. Bovine mastitis. 1st ednSatish serial publishing house; Delhi, India: p. 231–312.
crossref
Sharma N, Rho GJ, Hong YH, Kang TY, Lee HK, Hur TY, Jeong DK. 2012a. Bovine mastitis: An Asian Perspective. Asian J Anim Vet Adv 7:454–476.
crossref
Sharma N, Singh NK, Bhadwal MS. 2011. Relationship of Somatic Cell Count and Mastitis: An Overview. Asian-Aust J Anim Sci 24:429–438.
crossref pdf
Shekhar C, Kumar S. 2011. Quality of buffalo milk procured from milk vendors-a case study. Ind J Anim Res 45:223–225.

Shekhar C, Motina E, Kumar S. 2010. Microbiological quality of raw milk and its public health significance. J Dairying Foods Home Sci 29:15–18.

Siebert JW, Alejandro L, Sung-Yong K. 2001. The commercial potential of new dairy products from membrane technology. J Food Distrib Res 3:24–33.

Sienkiewicz T, Riedel CL. 1990. Whey and whey utilization. 2nd EdVerlag Th. Mann, Gelsenkirchen-Buer; Germany:

Stack A, Sillen G. 1998. Bactofugation of liquid milks. Nutr Food Sci 98:280–282.
crossref
Tang X, Fint SH, Brooks JD, Bennett RJ. 2009. Factors affecting the attachment of micro-organisms isolated from ultrafiltration and reverse osmosis membranes in dairy processing plants. J Appl Microbiol 107:443–451.
crossref pmid
Vadi PK, Rizvi SSH. 2001. Experimental evaluation of a uniform transmembrane pressure crossflow microfiltration unit for the concentration of micellar casein from skim milk. J Memb Sci 189:69–82.
crossref
Van der Horst HC, Timmer JMK, Robbertson T, Leenders J. 1995. Use of nanofiltration for concentration and demineralization in the dairy industry: Model for mass transport. J Memb Sci 104:205–218.
crossref
Van Leeuwen J, Freeman H, Sutherland J, Jameson W. 1987. European Patent WP 0 120 879 B1

Van Reis R, Zydney AL. 2007. Bioprocess membrane technology. J Memb Sci 297:16–50.
crossref
Van Rijn CJ, Kromkamp J. 2001. Method for filtering milk. WO Patent 0209527

Visvanathan C, Ben R. 1989. Aim, application of an electric field for the reduction of particle and colloidal fouling in cross flow microfiltration. Sep Sci Technol 24:383–398.
crossref
Vourch M, Balannec B, Chaufer B, Dorange G. 2005. Nanofiltration and reverse osmosis of model process waters from the dairy industry to produce water for reuse. Desalination 172:245–256.
crossref
Wakeman RJ, Williams CJ. 2002. Additional techniques to improve microfiltration. Sep Purif Technol 26:3–18.
crossref
Winston Ho WS, Sirkar KK. 1992. Membrane Handbook. Winston Ho WS, Sirkar KK, editorsVan Nostrand Reinhold; p. 3–16.



Editorial Office
Asian-Australasian Association of Animal Production Societies(AAAP)
Room 708 Sammo Sporex, 23, Sillim-ro 59-gil, Gwanak-gu, Seoul 08776, Korea   
TEL : +82-2-888-6558    FAX : +82-2-888-6559   
E-mail : editor@animbiosci.org               

Copyright © 2024 by Asian-Australasian Association of Animal Production Societies.

Developed in M2PI

Close layer
prev next