Effects of Replacing Dry-rolled Corn with Increasing Levels of Corn Dried Distillers Grains with Solubles on Characteristics of Digestion, Microbial Protein Synthesis and Digestible Energy of Diet in Hair Lambs Fed High-concentrate Diets

Article information

Asian-Australas J Anim Sci. 2013;26(8):1152-1159
Research Institute of Veterinary Sciences, University Autonomous of Baja California, México
*Corresponding Author: Alejandro Plascencia. Tel: +52-686-563 6906 (111), Fax: +52-686-5636907, E-mail: aplas_99@yahoo.com
1Veterinary School, University Autonomous of Sinaloa, México.
2Department of Animal Science, University of California, Davis, USA.
Received 2013 January 22; Accepted 2013 March 25; Revised 2013 April 01.

Abstract

Four male lambs (Katahdin; average live weight 25.9±2.9 kg) with “T” type cannulas in the rumen and proximal duodenum were used in a 4×4 Latin square experiment to evaluate the influence of supplemental dry distillers grain with solubles (DDGS) levels (0, 10, 20 and 30%, dry matter basis) in substitution for dry-rolled (DR) corn on characteristics of digestive function and digestible energy (DE) of diet. Treatments did not influence ruminal pH. Substitution of DR corn with DDGS increased ruminal neutral detergent fiber (NDF) digestion (quadratic effect, p<0.01), but decreased ruminal organic matter (OM) digestion (linear effect, p<0.01). Replacing corn with DDGS increased (linear, p≤0.02) duodenal flow of lipids, NDF and feed N. But there were no treatment effects on flow to the small intestine of microbial nitrogen (MN) or microbial N efficiency. The estimated UIP value of DDGS was 44%. Postruminal digestion of OM, starch, lipids and nitrogen (N) were not affected by treatments. Total tract digestion of N increased (linear, p = 0.04) as the DDGS level increased, but DDGS substitution tended to decrease total tract digestion of OM (p = 0.06) and digestion of gross energy (p = 0.08). However, it did not affect the dietary digestible energy (DE, MJ/kg), reflecting the greater gross energy content of DDGS versus DR corn in the replacements. The comparative DE value of DDGS may be considered similar to the DE value of the DR corn it replaced up to 30% in the finishing diets fed to lambs.

INTRODUCTION

During the production process of corn dry distillers grain with solubles (DDGS), protein, minerals, fat and fiber are concentrated three-fold as co-products when compared with corn. Therefore, corn DDGS contains approximately 30% crude protein (CP, 52% ruminal undegradable intake protein, UIP) and 11% fat (NRC, 2000), and often costs less than corn (USDA, 2010). Historically DDGS has primarily been fed to beef cattle, dairy animals include dairy sheep, swine and poultry (Rosentrater, 2012). Even though DDGS should be appropriate as a feed ingredient for sheep, there are limited reports in terms of the effects on digestive function and the energy value of DDGS for this species. The high potential of the nutritional value of DDGS can be useful for replacing dry-rolled (DR) or steam-flaked corn in growing-finishing diets of beef cattle (Klopfenstein, 2008). However, it appeared that the feed value of distillers grains may vary by level of inclusion (Uwituze et al., 2010) and by the type of processing (DR or steam-flaked) of the corn grain that is replaced (May et al., 2009; Luebbe et al., 2012). The optimal responses (daily weight gain and feed efficiency) in feedlot cattle when DDGS has replaced corn grain in finishing diets have been observed with moderate levels (i.e. 20%) of DDGS inclusion as a replacement of steam-flaked grain (May et al., 2009; Uwituze et al., 2010; Luebbe et al., 2012). Leupp et al. (2009) have reported that replacing DR corn with up to 60% DDGS in 70% concentrate diets resulted in no adverse effects on total tract OM digestion in steers, although ruminal OM digestion decreased and microbial production efficiency increased with increasing DDGS. Compared to steers, lambs has a greater ability to effectively utilize DR corn (Theurer, 1986); thus, the associative effects as a result of the replacement of DR corn with DDGS can have a different impact on nutrient digestion in fattening lambs. However, very little information is available on the effects of DDGS replacing DR corn on site and the extent of digestion of nutrients and digestible energy (DE) in lambs fed a high-energy diet.

Consequently, the objective of this study was to determine the effects of DDGS supplementation levels replacing DR corn on digestive function in lambs fed a high-energy DR corn-based diet.

MATERIAL AND METHODS

Animals, diets and sampling

The trial was conducted at the Ruminant Metabolism Experimental Unit of the Instituto de Investigaciones en Ciencias Veterinarias of the Universidad Autónoma de Baja California, located 10 km south of Mexicali City in northwestern México (32° 40′ 7”N and 115° 28′ 6”W). The area is about 10 m above sea level, and has Sonoran desert conditions (BWh classification according Köppen). All animal management procedures were conducted within the guidelines of locally-approved techniques for animal use and care (NOM-051-ZOO-1995: humanitarian care of animals during mobilization of animals; NOM-062-ZOO-1995: technical specifications for the care and use of laboratory animals. Livestock farms, farms, centres of production, reproduction and breeding, zoos and exhibition hall, must meet the basic principles of animal welfare; NOM-024-ZOO-1995: animal health stipulations and characteristics during transportation.

Four male lambs (Katahdin; average live weight 25.9±2.9 kg) with “T” type cannulas in the rumen and proximal duodenum (4 cm from the phyloric sphincter) were used in a 4×4 Latin square experiment to evaluate the influence of supplemental DDGS levels in the substitution of DR corn on characteristics of digestive function. Four dietary treatments were compared: i) Control (0% DDGS); ii) 10% DDGS; iii) 20% DDGS; and iv) 30% DDGS. Diets were formulated to be isocaloric but not isonitrogenous, because the protein level increases as the level of DDGS replacing corn in the diet increased (Table 1). Chromic oxide (used as a source of chromium to estimate nutrient flow and coefficient of digestion) was added to the diets. Chromic oxide (4 g/kg of diet air dry basis) was premixed with minor ingredients (urea and mineral supplement composed of limestone and trace mineral salts) before incorporation into complete mixed diets. White corn was used as source of grain in the form of a commercial blend obtained from Mexico. Corn was prepared by passing whole corn through rollers (46×61 cm rolls, 5.5corrugations/cm; Memco, Mills Rolls, Mill Engineering & Machinery Co., Oklahoma, CA) and machinery that had been adjusted so that the kernels were broken into a bulk density of 0.70 kg/L. The forage source of diet (sudangrass hay) was ground in a hammer mill (Bear Cat #1A-S, Westerns Land and Roller Co., Hastings, NE) with a 3.81cm screen, before incorporation into complete mixed diets. The source of DDGS used was a corn DDGS named for its appearance (color) as “Golden” and was obtained in an ethanol production facility with a 0.8% maximal content of sulfur (Pinal Energy LLC, Maricopa, AZ). All lambs received ad libitum access to the corn-basal diet (0% DDGS) for 14 d before the initiation of the trial. To avoid refusals, feed intake (as feed basis) was restricted to 750 g/d (90% of ad libitum intake of lambs during the 14-d preliminary period). As result to their intake level, the crude protein intake and energy intake (Table 2) meet the requirements for a lamb of 26 kg BW has a weight gain of 100 g/d (NRC, 2007). Lambs were maintained in individual metabolism crates (1.2×1.6×0.7 m) in an indoor facility with access to water at all times. Diets were fed in two equal proportions at 08:00 and 20:00 hours daily. Experimental periods consisted of a 17-d diet adjustment period followed by a 4-d collection period. During the collection period, duodenal and fecal samples were taken from all lambs twice daily as follows: d 1, 07:50 and 13:50 h; d 2, 09:00 and 15:00 h; d 3, 10:50 and 16:50 h; and d 4, 12:00 and 18:00 h. Individual samples consisted of 150 ml duodenal chyme and total fecal material. Samples from each lamb and within each collection period were composited for analysis. During the final day of each collection period, a ruminal sample was obtained from each lamb 4 h after feeding via the ruminal cannula. Ruminal fluid was taken from the ruminal ventral sac using tygon tubing (i.d. 0.95 cm; USP Lima, Ohio) adapted to a 100 ml syringe (Medical plastic appliance, Jiangzu, China), and the pH was determined (Orion 261S, Fisher Scientific, Pittsburgh, PA) on fresh samples. Upon completion of the trial, approximately 4 h after feeding a total of 2 L of ruminal fluid was obtained from all lambs. Total ruminal fluid was composited and poured in a closed jar protected from light and was mixed (1:1) with a saline solution warmed up to 40 to 45°C and immediately taken to the laboratory for the isolation of ruminal bacteria via differential centrifugation (Bergen et al., 1968). The microbial isolate served as the purine: N reference for the estimation of microbial nitrogen (MN) contribution to chyme entering the small intestine (Zinn and Owens, 1986).

Ingredients and composition of experimental diets fed to lambs (% of dry matter, DM)

Composition and density of corn dried distillers grains with solubles (DDGS) and dry-rolled corn (DRC) determined by analyses and corresponding tabular values (NRC, 2007)

Sample analysis and calculations

The bulk density of DR corn and DDGS was measured using a standard bushel tester (OHAUS grain scale Model 8324915, Parssipani, NJ, USA) following the method prescribed by the USDA (1999).

Ingredients (DDGS and DR corn), feed, and duodenal and fecal samples were subjected to the following analysis: Dry matter (DM, oven drying at 105°C until no further weight loss; method 930.15, AOAC, 2000); ash (method 942.05; AOAC, 2000), Kjeldahl nitrogen (method 984.13; AOAC, 2000); neutral detergent fiber (NDF; Van Soest et al., 1991, corrected for NDF-ash) incorporating heat stable α-amylase (Ankom Technology, Macedon, NY) at 1 ml per 100 ml of NDF solution (Midland Scientific, Omaha, NE); lipids (acid chloroform-methanol extraction; Zinn, 1994); chromic oxide (Hill and Anderson, 1958); and starch (Zinn, 1990). In addition, gross energy (GE, using the adiabatic bomb model 1271; Parr Instrument Co., Moline, IL. USA) was determined for feed and fecal samples. Ammonia N (method 941.04; AOAC, 2000) and purines (Zinn and Owens, 1986) were determined in duodenal samples. Organic matter (OM) of feed, duodenal, and fecal samples was determined by difference between DM and ash content. Microbial OM and N leaving the abomasum were calculated using purines as a microbial marker (Zinn and Owens, 1986). Organic matter that had fermented in the rumen was considered equal to OM intake minus the difference between the amount of total OM reaching the duodenum and the microbial OM reaching the duodenum. Feed N escape into the small intestine was considered equal to total N leaving the abomasum minus ammonia-N and MN and, thus, included any endogenous contributions.

Statistical design and analysis

The experimental design for this study was a 4×4 Latin square. Statistical data were analyzed using the MIXED procedure of SAS (2004). Fixed effects consisted of treatments, and random effects consisted of lambs and period. The statistical model for the trial was as follows:

Yijk=μ+Li+Pj+Tk+Eijk
where: Yijk is the response variable, μ is the common experimental effect, Li is the lamb effect, Pj is the period effect, Tk is the treatment effect and Eijk is the residual error. Treatment effects were tested for the following orthogonal components: i) linear effect of DDGS level; ii) quadratic effect of DDGS level; and iii) cubic effect of DDGS level. Coefficients for polynomial contrasts (linear, quadratic and cubic effects of DDGS level) with equal spacing (0, 10, 20 and 30%) were determined according to SAS (2004). Contrasts were considered significant when the p-value was p≤0.05, and as a tendency approaching significance with a p-value of p≤0.10.

RESULTS AND DISCUSSION

Physical and chemical characteristics of DDGS and replaced corn

The physicochemical composition of DDGS and corn used in the trial and their relative values according to the NRC (2007) are shown in Table 2. The bulk density of DDGS obtained here corresponds closely to the average bulk density (bulk density varied between 0.389 and 0.502 kg/L) reported previously by Rosentrater (2006). While that bulk density of DR white corn was 40% greater than that reported by Plascencia et al. (2011); thus, there was greater coarse-processing of the corn used in the current study. The nutrient composition of white corn used in the present experiment was consistent with previous reports (Sánchez et al., 2007; Plascencia et al., 2011). Compared to the values assigned to DDGS by the NRC (2007), the relative values of CP, NDF, lipids and ash were 0.90, 0.99, 0.85, and 0.93, respectively. According to the NRC (2007), the main constituent is the NDF, followed by the CP, although this proportion can be changed by the quantity of solubles added during the process (Kim et al., 2008). As a result, much of the variation in the composition of DDGS can be attributed to plant-to-plant differences in the proportions of distillers solubles added during processing (Spiehs et al., 2002; Kim et al., 2008). Due to the greater lipids content of DDGS than that of the DR corn, and compared to the control diet, increasing the DDGS level in the diet increased (linear component; p<0.01, Table 3) the lipid intake by 7.0, 11.7 and 15.8 g/d to 10, 20 and 30% DDGS levels, respectively. These values represent a concentration of 8.8% of the total lipids in DDGS and correspond closely to the total lipids determined by analysis (Table 2) and those reported in DDGS previously (NRC, 2000; Srinivasan et al., 2005; Leupp et al., 2009; Berger and Singh, 2010). The average ash content was very similar compared to the results obtained by Spiehs et al. (2002) and Belyea et al. (2004) but was nearly 50% lower than the average obtained by Bhadra et al. (2007).

Effects of replacing dry-rolled corn with increasing levels of corn dried distillers grains with solubles (DDGS) on characteristics of digestion

Characteristics of ruminal pH and site and extent of digestion

The treatment effects on ruminal pH and site and extent of digestion are shown in Table 3. The ruminal pH (sampling 4 h postpandrium) averaged 6.20±0.29, and was not affected (p≥0.15) by treatment, even though the starch intake decreased (Table 3; linear component, p<0.01) with greater dietary DDGS levels. This could be due to the potential acidity of DDGS, which came from H2SO4, a standard treatment in the ethanol production industry (McAloon et al., 2000). In this sense, Felix and Loerch (2011) reported that feeding DDGS (with S content of 0.74%) at greater inclusions (60%) reduced ruminal pH in cattle. However, similar to our results, previous studies reported no differences in ruminal pH when 20% (Peter et al., 2000) or 40% (Ham et al., 1994) DDGS was included in finishing diets to steers. In contrast, Leupp et al. (2009) observed a linear increase in ruminal pH as DDGS level increased from 15 to 60% in the substitution of DR corn.

Even when DM intake was very similar (p≥0.79) among treatments, as a result of different chemical composition among DR and DDGS treatments (Table 2), replacing DR corn with DDGS increased (linear, p<0.01) NDF, lipids and N intakes and decreased (linear, p<0.01) the starch intake.

Substitution of DR corn with DDGS did not influence ruminal, post-ruminal or the apparent total tract digestion of starch averaging 87.2±2.8, 90.4±3.9 and 98.7±0.6% to ruminal, post-ruminal and total tract digestion, respectively. Those starch digestion values are in closely agreement with those observed to lambs fed a DR corn based finishing diet (Green et al., 1987; Larson et al., 1993; Ortega-Cerrilla and Mendoza, 2003). Previous studies (May et al., 2008; Corrigan et al., 2009) which were conducted with steers, reported that the substitution of DR corn with DDGS did not influence site or extent digestion of starch. Starch digestion in steers is not greatly affected by starch intake over a range of 1 to 5 kg/d (approximately 2.5 to 12.5 g of starch/kg of BW, Huntington et al., 2006). In the present study, the range of starch intake was 9.1 to 12 2 g of starch/kg BW. Therefore, the absence of effects with DDGS substitution on starch disappearance in the present study is expected.

Ruminal NDF digestion increased (quadratic effect, p<0.01) with DDGS substitution. DDGS is a source of readily digestible non-forage fiber (Ham et al., 1994) and its fiber particles are very small. Therefore, rumen microbes could degrade easily (Bhadra et al., 2007). However, the replacement of DR corn with increasing levels of DDGS decreased (linear effect, p<0.01) the ruminal digestion of OM. This reduction is expected, and is attributable to the relative differences in the ruminal digestion of NDF (48.3%) vs starch (88.2%), and the ruminal indigestibility of dietary fat itself (Zinn, 1988). Moreover, it is well known that fat has negative effect on ruminal digestion. Therefore, the dose-dependent decrease in NDF digestion among the DDGS treatments (10, 20 and 30%) also seems to show negative effect of fat.

There were no treatment effects on the flow of MN into the small intestine (p≥0.56) and ruminal microbial efficiency (flow of MN to the small intestine as a proportion of OM fermented; p≥0.17). The substitution of DR corn with DDGS tended to increase (linear effect, p = 0.07) the flow of N to the small intestine. However, the ruminal N efficiency (flow of non-endogenous N to the small intestine as a proportion of N intake) decreased (linear effect, p = 0.02) with increasing DDGS supplementation. Decreased N efficiency with increasing DDGS-N intake is expected due to the proportional decrease in MN contribution as a function of N intake (whereas MN flow to the small intestine was similar across treatments, its contribution to intestinal N supply decreased inversely with N intake). The ruminal digestion of feed N was not affected (p≥0.20) by DDGS substitution. Considering the rumen undegradable intake protein (UIP) for DR corn as 55% (NRC, 1985b), then the value of UIP for DDGS averaged 44%. This value is less than the current tabular value (52%; NRC, 2000). Prior estimates of UIP for DDGS have ranged from 40 to 70% (NRC, 2000; Cao et al., 2009; Leupp et al., 2009; Brake et al., 2010; Islas and Soto-Navarro, 2011). High variation in UIP values may be due to the source and method of processing (Gunn et al., 2009; Hersom et al., 2010), and the proportion of solubles returned to grain solid residues in the DDGS mixture (Cao et al., 2009). Gilbery et al. (2006) observed that at least 87% of the N in corn distiller solubles was degraded in the rumen.

There were no treatment effects (p≥0.22) on post-ruminal digestion of OM and N. However, the post-ruminal digestion of NDF increased (quadratic effect, p = 0.01), with a maximal level of 30% of DDGS. This effect may occur as a compensation of digestion of digestible NDF, which generally occurred in the hindgut when ruminal NDF digestion was low (Gressley et al., 2011), or may be due by analytical mistakes in dietary fiber fractions in duodenal samples. Compared to 10 and 20% DDGS levels, a 30% DDGS level showed an average numerically decrease of 15.2% (Table 3) in the value of NDF ruminal digestion.

Post-ruminal lipids digestion was similar (p≥0.56) across treatments, averaging 78.8%. Post-ruminal lipids digestion (LD, %) is largely a function of total lipid intake (LI) expressed as grams of lipids/kg BW (LD, % = 83.18-4.52LI-0.68LI3, Zinn, 1994). In the present study, the lipids content of DDGS diets were 4.7, 5.4 and 5.9% for 10, 20 and 30% DDGS levels, respectively. According to dry matter intakes for DDGS diets (Table 3) and the average BW of lambs (25.9 kg), the lipid consumptions of the DDGS treatments would equate to 1.24, 1.42, and 1.58 g/kg BW, for the 10, 20 and 30% DDGS diets, respectively. Thus, dietary lipid intake was below of the 1.6 g/kg of BW suggested by Zinn (1994) as being the optimum digestion of lipids.

DDGS levels tended to increase (linear effect, p = 0.06) the total tract NDF digestion. This tendency in the digestion of NDF reflects the increased intake of highly digestible NDF from diets containing DDGS. However, consistent with the results of Corrigan et al. (2009), the level of DDGS substitution for DR corn decreased (linear effect, p<0.01) the total tract OM digestion. As with ruminal digestion, the reduction in total tract OM digestion was expected, and was largely attributable to relative differences in the total tract digestion of NDF (58%) versus starch (99%). Similar to previous reports in which the lipids intake was moderate (i.e. <6%) (Zinn and Plascencia, 1993; Plascencia et al., 1999; Uwituze et al., 2010), increases on lipid intake increase fecal excretion of lipids (p = 0.02) with no differences in lipids total tract digestion. Consistent with Leupp et al. (2009) and Brake et al. (2010), the total tract apparent N digestion increased (linear effect, p = 0.04) with the level of DDGS substitution. However, this effect may be more of a function of the increased N content of the diet brought about by the replacements (Holter and Reid, 1959). Adjusting for metabolic protein fecal loss (NRC, 1985a), the true digestion of protein in the present study averaged 91.8% that was similar to the average of previous measurements summarized by the NRC (1985a).

Consistent with effects on total tract OM digestion, the level of DDGS substitution for DR corn tended to decrease (linear effect, p = 0.08) the digestibility of GE, however this did not affect (p = 0.25) the dietary DE (MJ/kg), reflecting the greater gross energy content of DDGS versus DR corn in the replacements (Table 2).

CONCLUSION

Under the conditions of the current experiment, it was concluded that DDGS is appropriate for use as a feed ingredient in the finishing diets of lambs. The estimated UIP value of DDGS used in this study (44%) was less than current tabular estimates (52%; NRC, 2000). As a result of differences in the proportion of starch:NDF content between DDGS and replaced corn, the lower ruminal and total tract digestion of OM in lambs fed DDGS diets was mainly attributable to relative differences in the total tract digestion of NDF versus starch. However, it did not affect dietary DE (MJ/kg), reflecting the greater gross energy content of DDGS versus corn in the replacements. Accordingly, the comparative DE value of DDGS, included up to 30% in the finishing diets of lambs, may be considered similar to the DE value of the DR corn it replaced in the finishing diets fed to lambs. An additional consideration is that the use of DDGS as an alternative feed for fattening lambs depends on the relative price of DDGS and corn.

References

AOAC. 2000. Official methods of analysis 17th ednth ed. Association of Official Analytical Chemists. Gaithersburg, Maryland:
Belyea RL, Rausch KD, Tumbleson ME. 2004;Composition of corn and distillers’ dried grains with solubles from dry grind ethanol processing. Bioresour Technol 94:293–298.
Bhadra R, Muthukumarappan K, Rosentrater KA. 2007. Characterization of chemical and physical properties of distillers dried grain with solubles (DDGS) for value added uses. Paper No. 077009. In : ASABE Annual International Meeting. Minneapolis, Minnesota.
Bergen WG, Purser DB, Cline JH. 1968;Effect of ration on the nutritive quality of rumen microbial protein. J Anim Sci 27:1497–1501.
Berger L, Singh V. 2010;Changes and evolution of corn co-products for beef cattle. J Anim Sci 88:E143–E150.
Brake DW, Titgemeyer EC, Jones ML, Anderson DE. 2010;Effect of nitrogen supplementation on urea kinetics and microbial use of recycled urea in steers consuming corn-based diets. J Anim Sci 88:2729–2740.
Cao ZJ, Anderson JL, Kalscheur KF. 2009;Ruminal degradation and intestinal digestibility of dried or wet distillers grains with increasing concentrations of condensed distillers solubles. J Anim Sci 87:3013–3019.
Corrigan ME, Erickson GE, Klopfenstein TJ, Luebbe MK, Vander Pol KJ, Meyer NF, Buckner CD, Vanness SJ, Hanford KJ. 2009;Effect of corn processing method and corn wet distiller’s grains plus solubles inclusion level in finishing steers. J Anim Sci 87:3351–3362.
Felix TL, Loerch SC. 2011;Effects of haylage and monensin supplementation on performance, carcass characteristics, and ruminal metabolism of feedlot cattle fed diets containing 60% dried distillers grains. J Anim Sci 89:2614–2623.
Gilbery TC, Lardy GP, Soto-Navarro SA, Bauer ML, Caton JS. 2006;Effects of corn condensed distillers solubles supplementation on ruminal fermentation, digestion, and in situ disappearance in steers consuming low-quality hay. J Anim Sci 84:1468–1480.
Green DA, Stock RA, Goedeken FK, Klopfenstein TJ. 1987;Energy value of corn wet milling by-product fed for finishing ruminant. J Anim Sci 65:1655–1666.
Gressley TF, Hall MB, Armentano LE. 2011;Ruminant Nutrition Symposium: Productivity, digestion and health responses to hindgut acidosis in cattle. J Anim Sci 89:1120–1130.
Gunn PJ, Weaver AD, Lemenager RP, Gerrard DE, Claeys MC, Lake SL. 2009;Effects of dietary fat and crude protein on feedlot performance, carcass characteristics, and meat quality in finishing steers fed differing levels of dried distillers grains with solubles. J Anim Sci 87:2882–2890.
Ham GA, Stock RA, Klopfenstein TJ, Larson EM, Shain DH, Huffman RP. 1994;Wet corn distillers byproducts compared with dry corn distillers grains with solubles as a source of protein and energy for ruminants. J Anim Sci 72:3246–3257.
Hersom MJ, Boss DL, Wagner JJ, Zinn RA, Branine ME. 2010;Alpharma Beef Cattle Nutrition Symposium: Alternative energy sources for beef cattle finishing diets. J. Anim. Sci 88(E. Suppl.):E121–E122.
Hill FN, Anderson DL. 1958;Comparison of metabolizable energy and productive determinations with growing chicks. J Nutr 64:587–603.
Holter JA, Reid JT. 1959;Relationship between the concentrations of crude protein and apparently digestible protein in forages. J Anim Sci 18:1339–1349.
Huntington GB, Harmon DL, Richard CJ. 2006;Alpharma Beef Cattle Nutrition Symposium: Challenging the limits of caloric intake in feedlot cattle sites, rates, and limits of starch digestion and glucose metabolism in growing cattle. J Anim Sci 84:E14–E24.
Islas A, Soto-Navarro SA. 2011;Effect of supplementation of dried distillers grains with solubles on forage intake and characteristics of digestion of beef heifers grazing small-grain pasture. J Anim Sci 89:1229–1237.
Kim Y, Mosier NS, Hendrikson R, Ezeji T, Blascheck H, Dienn B, Cotta M, Dale B, Ladish ML. 2008;Composition of corn dry-grind ethanol by-products: DDGS, wet cake, and thin stillage. Bioresour Technol 99:5165–5176.
Klopfenstein TJ, Erickson GE, Bremer VR. 2008;Board-Invited Review: Use of distillers by-products in the beef cattle feeding industry. J Anim Sci 86:1223–1231.
Larson ME, Stock RA, Klopfenstein TJ, Sindt MH, Shain DH. 1993;Energy value of hominy feed for finishing ruminants. J Anim Sci 71:1092–1099.
Leupp JL, Lardy GP, Karges KK, Gibson ML, Caton JS. 2009;Effects of increasing level of corn distillers dried grains with solubles on intake, digestion, and ruminal fermentation in steers fed seventy percent concentrate diets. J Anim Sci 87:2906–2912.
Luebbe MK, Patterson JM, Jenkins KH, Buttrey EK, Davis TC, Clark BE, McCollum FT III, Cole NA, MacDonald JC. 2012;Wet distillers grains plus solubles concentration in steam-flaked corn-based diets: Effects on feedlot cattle performance, carcass characteristics, nutrient digestibility, and ruminal fermentation characteristics. J Anim Sci 90:1589–1602.
May ML, Hands MJ, Quinn MJ, Wallace JO, Reinhardt DD, Murray L, Drouillard JS. 2008;Digestibility of dried distiller’s grains with solubles in steam-flaked or dry-rolled corn diets. Kansas State University Beef Cattle Res Rpt Progress 95:80–85.
May ML, Quinn MJ, Reinhardt CD, Murray L, Gibson ML, Karges KK, Drouillard JS. 2009;Effects of dry-rolled or steam-flaked corn finishing diets with or without twenty-five percent dried distillers grains on ruminal fermentation and apparent total tract digestion. J Anim Sci 87:3630–3638.
McAloon A, Taylor F, Yee W, Ibsen K, Wooley R. 2000. Determining the cost of producing ethanol from cornstarch and lignocellulosic feedstocks Technical Report (NREL/TP-580-28893). NREL. Golden, Colorado:
National Research Council. 1985a. Ruminant nitrogen usage National Academy Press. Washington, DC:
National Research Council. 1985b. Nutrient requirement of sheep 6th Edth ed. National Academy Press. Washington, DC:
National Research Council. 2000. Nutrient requirements of beef cattle 7th Edth ed. National Academy of Press. Washington, DC:
National Research Council. 2007. Nutrient requirement of small ruminant Sheep, Goats, Cervids, and New World Camelids National Academy Press. Washington, DC:
Ortega-Cerrilla M, Mendoza MG. 2003;Starch digestion and glucose metabolism in the ruminant: A review. Interciencia 28:380–386.
Peter CM, Faulkner DB, Merchen NR, Parrett DF, Nash TG, Dahlquist JM. 2000;The effects of corn milling co-products on growth performance and diet digestibility by beef cattle. J Anim Sci 78:1–6.
Plascencia A, Estrada M, Zinn RA. 1999;Influence of free fatty acid content on the feeding value of yellow grease in finishing diets for feedlot cattle. J Anim Sci 77:2603–2609.
Plascencia A, Bermudez R, Cervantes M, Corona L, Davila-Ramos H, López-Soto MA, May D, Torrentera N, Zinn RA. 2011;Influence of processing method on comparative digestion of white corn vs. conventional steam-flaked yellow dent corn in finishing diets for feedlot steers. J Anim Sci 89:136–141.
Plascencia A, Mendoza G, Vazquez C, Zinn RA. 2003;Relationship between body weight and level of fat supplementation on fatty acid digestion in feedlot cattle. J Anim Sci 81:2653–2659.
Rosentrater KA. 2006;Some physical properties of distillers dried grains with solubles (DDGS). Appl Eng Agr 22:589–595.
Rosentrater KA. 2012. Feeding DDGS in other animals. Distiller grain, production properties and utilization In : Lui K, Rosentrater KA, eds. CRC Press. Boca Raton, Florida: p. 391–397.
SAS Institute Inc. 2004. SAS/STAT user’s guide: Version 9.1 SAS Institute Inc. Cary, North Caroline:
Spiehs M, J , Whitney MH, Shuron GC. 2002;Nutrient database for distiller’s dried grains with solubles produced from new ethanol plants in Minnesota and South Dakota. J Anim Sci 80:2639–2645.
Sánchez FC, Salinas MY, Vázquez GMC, Velázquez CGA, Aguilar GN. 2007;Efecto de las prolaminas del grano de maíz (Zea mays L.) sobre la textura de la tortilla. ALAN 57:295–301. (In Spanish).
Srinivasan R, Moreau RA, Rausch KD, Belyea RL, Tumbleson ME, Singh V. 2005;Separation of fiber from distillers dried grains with solubles (DDGS) using sieving and elutriation. Cereal Chem 82:528–533.
Theurer CB. 1986;Grain processing effects on starch utilization by ruminants. J Anim Sci 63:1649–1662.
USDA. 1999. Practical Procedures for Grain Handlers: Inspecting Grain United States Department of Agriculture – Grain Inspection, Packers, and Stockyards Administration; Washington, DC: Available from URL: http://151.121.3.117/pubs/primer.pdf (accessed July 13, 2012).
USDA. 2010. Energy balance for the corn ethanol industry Agricultural Economic Report No. 846 United States Dep. Agric. Washington, DC:
Uwituze S, Parsons GL, Shelor MK, Depenbusch BE, Karges KK, Gibson ML, Reinhardt CD, Higgins JJ, Drouillard JS. 2010;Evaluation of dried distillers grains and roughage source in steam-flaked corn. J Anim Sci 88:258–274.
Van Soest PJ, Robertson JB, Lewis BA. 1991;Methods for dietary fiber, neutral detergent fiber, and nonstarch polysaccharides in relation to animal nutrition. J Dairy Sci 74:3583–3597.
Zinn RA. 1988;Comparative feeding value of supplemental fat in finishing diets for feedlot steers supplemented with and without monensin. J Anim Sci 66:213–227.
Zinn RA. 1990;Influence of steaming time on site digestion of flaked corn in steers. J Anim Sci 68:776–781.
Zinn RA. 1994;Effects of excessive supplemental fat on feedlot cattle growth performance and digestive function. Prof Anim Sci 10:66–72.
Zinn RA, Plascencia A. 1993;Interaction of whole cottonseed and supplemental fat on digestive function in cattle. J Anim Sci 71:11–17.
Zinn RA, Owens FN. 1986;A rapid procedure for purine measurement and its use for estimating net ruminal protein synthesis. Can J Anim Sci 66:157–166.

Article information Continued

Table 1

Ingredients and composition of experimental diets fed to lambs (% of dry matter, DM)

Item Dried distillers grains plus solubles level (%)
0 10 20 30
Ingredient composition (%)
  Dry-rolled corn 74.50 64.50 54.50 44.50
  Dried distillers grains with solubles 0.00 10.00 20.00 30.00
  Soybean meal 5.00 5.00 5.00 5.00
  Sudan grass hay 10.00 10.00 10.00 10.00
  Tallow 1.50 1.50 1.50 1.50
  Molasses 6.10 6.10 6.10 6.10
  Chromium oxide 0.40 0.40 0.40 0.40
  Mineral premix1 2.50 2.50 2.50 2.50
Chemical composition2 (DM basis)
  Crude protein (%) 10.95 12.61 13.98 15.51
  Lipids (%) 3.70 4.68 5.38 5.95
  NDF (%) 16.04 19.75 22.55 26.12
  Gross energy (MJ/kg) 17.45 17.74 18.32 18.41
Calculated net energy3 (MJ/kg)
  Maintenance 8.66 8.66 8.66 8.66
  Gain 5.90 5.90 5.90 5.90
1

Mineral premix was composed by 64% limestone, 20% NaCl enriched with trace mineral and 16% urea. Mineral premix contained CP, 50%; Calcium, 28%; Phosphorous, 0.55%; Magnesium, 0.58%; Potassium, 0.65%; NaCl, 15%; vitamin A, 1,100 IU/kg; vitamin E, 11 UI/kg.

2

Dietary composition was determined by analyzing subsamples collected and composited throughout the experiment. Accuracy was ensured by adequate replication with acceptance of mean values that were within 5% of each other.

3

Based on tabular net energy (NE) values for individual feed ingredients (NRC, 1985) with the exception of supplemental fat, which was assigned NEm and NEg values of 25.1 and 19.87 MJ/kg, respectively (Zinn, 1988).

Table 2

Composition and density of corn dried distillers grains with solubles (DDGS) and dry-rolled corn (DRC) determined by analyses and corresponding tabular values (NRC, 2007)

Item DDGS DRC DDGS (NRC, 2007) DRC (NRC, 2007)
DM (%)1 94.2 91.4 90.0 88.0
CP (%)2 26.3 9.1 29.0 9.0
NDF (%)3 42.7 10.3 43.0 9.0
Starch (%) 4.3 69.4 - -
Lipids (%) 9.0 3.6 10.6 4.3
Ash (%) 5.6 1.7 6.0 2.0
Gross energy (MJ/kg) 20.38 17.41 - -
Density (g/L) 454 702 - -
1

DM = Dry matter.

2

CP = Crude protein.

3

NDF = Neutral detergent fiber.

Table 3

Effects of replacing dry-rolled corn with increasing levels of corn dried distillers grains with solubles (DDGS) on characteristics of digestion

Item DDGS in diet SEM1 Contrast p-value


0% 10% 20% 30% Linear Quadratic Cubic
Ruminal pH 6.08 6.15 6.25 6.33 0.11 0.15 0.99 0.92
Intake (g/d)
  DM2 679 685 684 689 23 0.79 0.98 0.91
  OM3 634 641 639 646 21 0.74 0.99 0.87
  NDF4 109a 135b 154c 180d 4 <0.01 0.95 0.49
  Starch 319a 272b 250bc 236c 9.9 <0.01 0.15 0.75
  N5 11.9a 13.8ab 15.3b 17.1c 0.44 <0.01 0.83 0.72
  Lipids 24.4a 35.6b 38.7bc 40.9c 1.1 <0.01 0.06 0.19
GE (MJ/d)6 11.8 12.1 12.5 12.7 0.40 0.17 0.87 0.86
Flow to duodenum (g/d)
  OM 351 379 382 393 16 0.13 0.64 0.68
  NDF 67a 64a 77a 102b 4.5 <0.01 0.02 0.83
  Starch 38 36 32 31 5.2 0.30 0.93 0.93
  N 14.6 15.6 16.2 17.3 0.92 0.07 0.93 0.83
  Nonammonia N 13.9 14.8 15.4 16.4 0.86 0.08 0.99 0.86
  MN7 8.26 8.67 8.41 7.63 0.96 0.63 0.56 0.97
  Feed N 5.61a 6.15a 7.00a 8.73b 0.47 <0.01 0.25 0.79
  Lipids 29.8a 37.2b 44.5b 46.6b 3.3 0.02 0.18 0.55
Ruminal digestion (%)
  OM 57.5a 54.4ab 53.4bc 50.8c 0.9 <0.01 0.83 0.41
  NDF 38.5a 52.2b 49.7b 43.2ab 2.7 0.38 <0.01 0.37
  Starch 88.2 86.9 87.1 87.0 1.7 0.66 0.75 0.83
  Feed N 52.8 55.7 54.3 48.7 2.9 0.36 0.20 0.98
Microbial efficiency8 23.3 22.9 21.6 19.4 1.9 0.17 0.65 0.98
N efficiency9 1.16 1.08 1.00 0.96 0.05 0.02 0.58 0.92
Postruminal digestion (%) leaving abomasums
  OM 66.6 65.7 65.3 62.6 2.1 0.22 0.68 0.77
  NDF 19.2ab 9.7a 14.3a 27.8b 2.9 0.06 0.01 0.69
  Starch 90.7 90.7 90.8 89.8 1.7 0.74 0.88 0.79
  N 77.0 77.2 76.1 77.1 1.2 0.86 0.69 0.56
  Lipids 80.5 78.7 79.9 79.2 2.7 0.88 0.32 0.72
Fecal excretion (g/d)
  DM 142a 154ab 130ab 173b 7.6 0.03 0.90 0.71
  OM 117a 130ab 133ab 147b 8.3 0.04 0.95 0.60
  NDF 53a 58ab 67bc 74c 3.7 <0.01 0.72 0.71
  Starch 3.4 3.3 3.1 3.3 0.57 0.83 0.77 0.85
  N 3.3 3.5 3.8 3.9 0.21 0.07 0.96 0.84
  Lipids 5.8a 7.9b 8.9b 9.7b 1.29 0.02 0.64 0.77
GE (MJ/d) 2.45a 2.66a 2.75a 3.04b 0.15 0.04 0.81 0.67
Total-tract digestion (%)
  DM 78.8a 77.5ab 76.7ab 74.9b 1.1 0.04 0.88 0.75
  OM 81.5 79.7 79.3 77.3 1.2 0.06 0.94 0.60
  NDF 51.1a 57.2ab 57.1ab 59.2b 2.3 0.06 0.42 0.44
  Starch 98.9 98.8 98.8 98.6 0.2 0.36 0.89 0.81
  N 72.0 74.4 75.4 76.9 1.3 0.04 0.74 0.79
  Lipids 76.2 77.8 77.0 76.4 0.9 0.61 0.47 0.66
DE (%)10 79.3 78.0 78.0 76.1 1.0 0.08 0.79 0.55
DE diet (MJ/kg) 13.8 13.8 14.3 13.9 0.21 0.37 0.53 0.25
a,b,c

Within rows, means followed by different letters are significantly different at p<0.05.

1

SEM = Standard error.

2

DM = Dry matter.

3

OM = Organic matter.

4

NDF = Neutral detergent fiber.

5

N = Nitrogen.

6

GE = Gross energy.

7

MN = Microbial nitrogen.

8

Microbial efficiency is expressed as duodenal MN, g/kg OM fermented in the rumen.

9

N efficiency is expressed as duodenal non-ammonia N, g/g N intake.

10

DE = Digestible energy.